STD Other Open Anyone else got these? Ultracapacitors for car starting

Anyone else got these? Ultracapacitors for car starting

Anyone else got these? Ultracapacitors for car starting

 
  • 0 Vote(s) - 0 Average
 
NZScott
HX30W 73/44mm

398
08-28-2016, 04:03 AM #1
Hello

One of my many other distractions from my Mercs...
I got inspired from this video and the others that followed it

https://www.youtube.com/watch?v=GPJao1xLe7w

https://www.youtube.com/watch?v=OvbuJwYnbvE



Basically ultracapacitors are "canned lightning" being able to charge and discharge current quicker than just about anything.

Pros:
The caps are rated for a million charge/discharge cycles. They'll outlast any vehicle you put them in
Each cell has a 9300A short circuit current (yikes)
Unaffected by temperature
Charge as quick as you can get current into them
Charge up to the voltage across them
Give high current until the voltage is way down (my 617 will keep cranking down to about 5V!)


Cons:
Capacity is far less than a battery. 18 of them worked out to be like 1/20th the capacity of a 88Ah 850CCA battery. With my 6, if you leave the headlights on for 5 mins you'll need a jump. At least it'll only take a few seconds to charge up Tongue
Self discharge - the pack voltage drops by itself a little bit, and every parasitic load will drop it even more. Was a problem in my corona but not in the merc at the moment with only a clock to run.
Overcharging - the only way to kill these is high voltage. Basically going over the rated voltage breaks down the materials inside. They would last just about forever if you were charging them to a silly low voltage though
Balancing - every cell in theory is slightly different so will charge to a different voltage, possibly meaning you could be overcharging a cell and killing it without a resistor or circuitry to bleed current around it. I'm looking into 2.5V zener diodes for this.
Voltage drops linearly with charge. So for anything needing a constant voltage you'll want a dc/dc converter or something.

Also a note, when putting capacitors in series, the capacitance is divided by the number of caps in series. So 3000F/6 = 500F

I bought a used Maxwell 48V module from ebay. 18x 2.7V 3000 farad caps. About $800 odd NZD - yup not cheap! Best $/cap though unless you buy a literal bus load (some buses and trams etc are ultracap powered, they charge at each stop). Maxwell make 2.85V ones and 3400F ones now.


   

Taking it apart

   

   

I made a box to put 6 in, 6*2.7 gives 16.2V so fine for a car. I cut the terminal posts off an old battery and bolted them on to the caps. Used it for about a month in my toymota, was rather annoying however as the pack would self discharge below 9V and the starter wouldn't crank. I got a solar panel (being a sunny place here) but never hooked it up.

   

Made a video too
https://www.youtube.com/watch?v=sSP8yfdBRx0


My dad's vectra had trouble starting recently so gave him the battery out of my '78, being euro and all, it was 480CCA and never had any trouble starting a 617 in winter. The genuine MB 850CCA that I got from the wagon I briefly had is a bit past it to crank but it good enough to keep the ultracaps topped up whiel the car sits on the driveway being worked on.


   

I have plans to install all 18 caps under the backseat -got the cable etc. 3 strings of 6. 3x500F=1500F. 18,900A short circuit current!!! I have a fuse + safety switch for disconnecting when working on the car wiring....

Ideally, you'd be best to use a hybrid battery/capacitor setup. The battery would keep voltage topped up as normal so you could run the radio etc, and the caps would be there just for cranking. Around here, the smallest 12V batteries (~12Ah) are still $50, so I'm going to keep with the 18 cap pack idea as I shouldn't have any issues, with the 5W solar panel especially.

Will I get my money back from them? Doubt it, but a fun experiment. I've never bought a car battery yet Tongue


1978 300D, 373,000km... OM617.912 with a Holset HX30W, 7.5mm IP, 711.113 5 speed (project car, 7 years off the road and counting ;/)
1977 250 270,000km (parts car)
1977 300D (ex 280) 500,000km

1981 240D 498,000
1975 HJ45 ???,000
2001 2.8TD Rodeo 4x2 - 456,000 - DD




NZScott
08-28-2016, 04:03 AM #1

Hello

One of my many other distractions from my Mercs...
I got inspired from this video and the others that followed it

https://www.youtube.com/watch?v=GPJao1xLe7w

https://www.youtube.com/watch?v=OvbuJwYnbvE



Basically ultracapacitors are "canned lightning" being able to charge and discharge current quicker than just about anything.

Pros:
The caps are rated for a million charge/discharge cycles. They'll outlast any vehicle you put them in
Each cell has a 9300A short circuit current (yikes)
Unaffected by temperature
Charge as quick as you can get current into them
Charge up to the voltage across them
Give high current until the voltage is way down (my 617 will keep cranking down to about 5V!)


Cons:
Capacity is far less than a battery. 18 of them worked out to be like 1/20th the capacity of a 88Ah 850CCA battery. With my 6, if you leave the headlights on for 5 mins you'll need a jump. At least it'll only take a few seconds to charge up Tongue
Self discharge - the pack voltage drops by itself a little bit, and every parasitic load will drop it even more. Was a problem in my corona but not in the merc at the moment with only a clock to run.
Overcharging - the only way to kill these is high voltage. Basically going over the rated voltage breaks down the materials inside. They would last just about forever if you were charging them to a silly low voltage though
Balancing - every cell in theory is slightly different so will charge to a different voltage, possibly meaning you could be overcharging a cell and killing it without a resistor or circuitry to bleed current around it. I'm looking into 2.5V zener diodes for this.
Voltage drops linearly with charge. So for anything needing a constant voltage you'll want a dc/dc converter or something.

Also a note, when putting capacitors in series, the capacitance is divided by the number of caps in series. So 3000F/6 = 500F

I bought a used Maxwell 48V module from ebay. 18x 2.7V 3000 farad caps. About $800 odd NZD - yup not cheap! Best $/cap though unless you buy a literal bus load (some buses and trams etc are ultracap powered, they charge at each stop). Maxwell make 2.85V ones and 3400F ones now.


   

Taking it apart

   

   

I made a box to put 6 in, 6*2.7 gives 16.2V so fine for a car. I cut the terminal posts off an old battery and bolted them on to the caps. Used it for about a month in my toymota, was rather annoying however as the pack would self discharge below 9V and the starter wouldn't crank. I got a solar panel (being a sunny place here) but never hooked it up.

   

Made a video too
https://www.youtube.com/watch?v=sSP8yfdBRx0


My dad's vectra had trouble starting recently so gave him the battery out of my '78, being euro and all, it was 480CCA and never had any trouble starting a 617 in winter. The genuine MB 850CCA that I got from the wagon I briefly had is a bit past it to crank but it good enough to keep the ultracaps topped up whiel the car sits on the driveway being worked on.


   

I have plans to install all 18 caps under the backseat -got the cable etc. 3 strings of 6. 3x500F=1500F. 18,900A short circuit current!!! I have a fuse + safety switch for disconnecting when working on the car wiring....

Ideally, you'd be best to use a hybrid battery/capacitor setup. The battery would keep voltage topped up as normal so you could run the radio etc, and the caps would be there just for cranking. Around here, the smallest 12V batteries (~12Ah) are still $50, so I'm going to keep with the 18 cap pack idea as I shouldn't have any issues, with the 5W solar panel especially.

Will I get my money back from them? Doubt it, but a fun experiment. I've never bought a car battery yet Tongue



1978 300D, 373,000km... OM617.912 with a Holset HX30W, 7.5mm IP, 711.113 5 speed (project car, 7 years off the road and counting ;/)
1977 250 270,000km (parts car)
1977 300D (ex 280) 500,000km

1981 240D 498,000
1975 HJ45 ???,000
2001 2.8TD Rodeo 4x2 - 456,000 - DD




NZScott
HX30W 73/44mm

398
09-10-2016, 02:27 AM #2
Nobody? I might be a pioneer of sorts with these for diesels Tongue


1978 300D, 373,000km... OM617.912 with a Holset HX30W, 7.5mm IP, 711.113 5 speed (project car, 7 years off the road and counting ;/)
1977 250 270,000km (parts car)
1977 300D (ex 280) 500,000km

1981 240D 498,000
1975 HJ45 ???,000
2001 2.8TD Rodeo 4x2 - 456,000 - DD




NZScott
09-10-2016, 02:27 AM #2

Nobody? I might be a pioneer of sorts with these for diesels Tongue



1978 300D, 373,000km... OM617.912 with a Holset HX30W, 7.5mm IP, 711.113 5 speed (project car, 7 years off the road and counting ;/)
1977 250 270,000km (parts car)
1977 300D (ex 280) 500,000km

1981 240D 498,000
1975 HJ45 ???,000
2001 2.8TD Rodeo 4x2 - 456,000 - DD




Greazzer
Superturbo

1,277
09-10-2016, 06:55 PM #3
How big? Weight?

Ninth Year Anniversary with STD on 1-9-2020

visit:  www.dieselfuelinjector.guru

Project 2018: Really get the car finished -- Turbo OM617 greater than 175 MPH goal.

RED W123 - left Germany as 240D in 1982.  Full AMG body kit less rear apron, 2:65LSD, five speed Getrag 717.400, manual steering, read leather interior, manual brake conversion, electric water pump (EWP), and a bunch of other goodies ...
Greazzer
09-10-2016, 06:55 PM #3

How big? Weight?


Ninth Year Anniversary with STD on 1-9-2020

visit:  www.dieselfuelinjector.guru

Project 2018: Really get the car finished -- Turbo OM617 greater than 175 MPH goal.

RED W123 - left Germany as 240D in 1982.  Full AMG body kit less rear apron, 2:65LSD, five speed Getrag 717.400, manual steering, read leather interior, manual brake conversion, electric water pump (EWP), and a bunch of other goodies ...

NZScott
HX30W 73/44mm

398
09-10-2016, 08:10 PM #4
http://www.maxwell.com/images/documents/...162013.pdf

So about 30lb for the whole module. That's with the case etc, but they're not light

6 of them take up about the same volume as the battery I had in there.


1978 300D, 373,000km... OM617.912 with a Holset HX30W, 7.5mm IP, 711.113 5 speed (project car, 7 years off the road and counting ;/)
1977 250 270,000km (parts car)
1977 300D (ex 280) 500,000km

1981 240D 498,000
1975 HJ45 ???,000
2001 2.8TD Rodeo 4x2 - 456,000 - DD




NZScott
09-10-2016, 08:10 PM #4

http://www.maxwell.com/images/documents/...162013.pdf

So about 30lb for the whole module. That's with the case etc, but they're not light

6 of them take up about the same volume as the battery I had in there.



1978 300D, 373,000km... OM617.912 with a Holset HX30W, 7.5mm IP, 711.113 5 speed (project car, 7 years off the road and counting ;/)
1977 250 270,000km (parts car)
1977 300D (ex 280) 500,000km

1981 240D 498,000
1975 HJ45 ???,000
2001 2.8TD Rodeo 4x2 - 456,000 - DD




Petar
7.5mm M pump

459
09-11-2016, 02:31 PM #5
They seem to be a great solution, especially for cold starts to boost the cranking amps. If I were you I would have a normal battery in parallel. So the battery charges the caps slowly and they boost cranking power. But they are just too expensive in my opionion... I would just buy a high quality battery with lots of CCA, maybe even two in parallel, and have money to spare for a superpump  Big Grin
Petar
09-11-2016, 02:31 PM #5

They seem to be a great solution, especially for cold starts to boost the cranking amps. If I were you I would have a normal battery in parallel. So the battery charges the caps slowly and they boost cranking power. But they are just too expensive in my opionion... I would just buy a high quality battery with lots of CCA, maybe even two in parallel, and have money to spare for a superpump  Big Grin

 
  • 0 Vote(s) - 0 Average
Users browsing this thread:
 1 Guest(s)
Users browsing this thread:
 1 Guest(s)